CVC PRODUCTS INC -- OCTOIL  -- 9150-00-993-6569
<pre>=====================  Product Identification  =====================

Product ID:OCTOIL
MSDS Date:10/01/1991
FSC:9150
NIIN:00-993-6569
=== Responsible Party ===
Company Name:CVC PRODUCTS INC
Address:525 LEE RD
Box:1886
City:ROCHESTER
State:NY
ZIP:14603
Country:US
Info Phone Num:716-458-2550
Emergency Phone Num:800-424-9300 (CHEMTREC)
Preparer's Name:MARY DIVINCENZO
CAGE:98079
=== Contractor Identification ===
Company Name:CVC PRODUCTS INC
Address:525 LEE RD
Box:1886
City:ROCHESTER
State:NY
ZIP:14603
Country:US
Phone:716-458-2550
CAGE:98079

=============  Composition/Information on Ingredients  =============

Ingred Name:PHTHALIC ACID, DIOCTYL ESTER;(DI 2 ETHYLHEXYL PHTHALATE)
    (DEHP) (MFR)
CAS:117-84-0
RTECS #:TI1925000
Fraction by Wt: 99%
OSHA PEL:5 MG/M3; 10 STEL
ACGIH TLV:5 MG/M3; 10 STEL
EPA Rpt Qty:5000 LBS
DOT Rpt Qty:5000 LBS

=====================  Hazards Identification  =====================

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES  Skin:NO  Ingestion:YES
Reports of Carcinogenicity:NTP:NO    IARC:NO	OSHA:NO
Health Hazards Acute and Chronic:NORMALLY NONE, UNLESS PRODUCT IS
    HEATED, RUSTED, OR SPILLED. CONCENTRATIONS ABOVE THE RECOMMENDED
    EXPOSURE LIMITS MAY CAUSE IRRITATION TO MUCOUS MEMBRANES AND UPPER
    RESPIRATORY TRACT. THE MAJOR TARGET  ORGANS SHOWING DEHP RELATED
    TOX IN ANIMALS ARE LIVER, TESTES, & FETUS. DEHP CAUSES LIVER
    ENLARGEMENT, (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:AND PEROXISOME PROLIFERATION IN
    RODENTS. VERY HIGH DIETARY LEVELS PRODUCED LIVER CANCER IN MICE &
    RATS OF BOTH SEXES (NTD 3RD ANNUAL REPORT, 134). DEHP ALSO CAUSED
    TESTICULAR DAMAGE AND REDUC ED FERTILITY IN MALES AND FETOTOXICITY
    AND TERATOGENICITY IN PREGANANT FEMALE RODENTS.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

=======================  First Aid Measures  =======================

First Aid:EYE:FLUSH WITH LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES
    LIFTING UPPER & LOWER LIDS OCCASIONALLY. GET MD. SKIN:REMOVE
    CONTAMINATED CLOTHING. WASH WITH SOAP & WATER. GET MD. INHAL:MOVE
    FROM EXPOSU RE. IF BREATHING DIFFICULT OR HAS STOPPED GIVE ARTF
    RESP OR O*2. GET MD. INGEST:GIVE 1-2 GLASSES OF WATER OR MILK.
    INDUCE VOMITING.

=====================  Fire Fighting Measures  =====================

Flash Point Method:COC
Flash Point:420F,216C
Extinguishing Media:WATER FOG, FOAM, CARBON DIOXIDE, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
    PROTECTIVE EQUIPMENT . BURNING OF PRODUCT WILL RESULT IN RELEASE OF
    TOXIC FUMES.
Unusual Fire/Explosion Hazard:NONE.

==================  Accidental Release Measures  ==================

Spill Release Procedures:WHEN MATERIAL IS IN CONTACT WITH HOT OBJECTS,
    AVOID EXCESSIVE BREATHING OF FUMES. REMOVE IGNITION SOURCES. FLOOD
    SPILLED OIL WITH WATER. COVER WITH EXCESS OF ABSORBENT INORGANIC
    MATERIAL. SWEEP UP AND  PLACE IN LABELED DRUM.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

======================	Handling and Storage  ======================

Handling and Storage Precautions:STORE IN WELL VENTILATED AREA AWAY
    FROM OXIDIZING AGENTS & SOURCES OF HEAT/IGNITION.
Other Precautions:AVOID REPEATED OR PROLONGED CONTACT WITH THE LIQUID
    AND INHALATION OF MIST OR VAPORS. DO NOT EAT OR SMOKE IN AREA WHERE
    THIS MATERIAL IS STORED.

=============  Exposure Controls/Personal Protection  =============

Respiratory Protection:NIOSH/MSHA APPROVED RESPIRATORS SHOULD BE
    PROVIDED FOR PROTECTION AGAINST ORGANIC VAPORS. RESPIRATORY
    PROTECTION SHOULD BE USED TO AVOID INHALATION OF EXCESSIVE AIR
    CONTAMINANTS.
Ventilation:VENTILATION USED TO CONTROL EMISSION OF AIR. MECHANICAL
    (GENERAL):GENERAL DILUTION VENTILATION.
Protective Gloves:NATURAL, NEOPRENE, POLYVINYL & NITRILE.
Eye Protection:CHEM WORK GOGG/FULL LENGTH FSHLD .
Other Protective Equipment:EMERGENCY EYE WASH STATIONS AND DELUGE
    SAFETY SHOWERS. WEAR CLEAN WORK CLOTHES.
Work Hygienic Practices:FOLLOW GOOD HYGIENIC PRACTICES TO AVOID
    POTENTIAL CHRONIC EFFECTS.
Supplemental Safety and Health
NONE SPECIFIED BY MANUFACTURER.

==================  Physical/Chemical Properties  ==================

Boiling Pt:B.P. Text:446F,230C
Vapor Pres:NEG @ 0C
Vapor Density:13.5
Spec Gravity:0.982 @ 25C
Solubility in Water:0.02%
Appearance and Odor:CLEAR LIQUID, MILD ODOR
Percent Volatiles by Volume:NEG

=================  Stability and Reactivity Data  =================

Stability Indicator/Materials to Avoid:YES
NONE SPECIFIED BY MANUFACTURER.
Stability Condition to Avoid:NONE.
Hazardous Decomposition Products:CO, CO*2, ORGANIC ACID.

====================  Disposal Considerations  ====================

Waste Disposal Methods:DISPOSE IN ACCORDANCE WITH LOCAL, STATE, AND
    FEDERAL REGULATIONS.

 Disclaimer (provided with this information by the compiling agencies):
 This information is formulated for use by elements of the Department
 of Defense.  The United States of America in no manner whatsoever,
 expressly or implied, warrants this information to be accurate and
 disclaims all liability for its use.  Any person utilizing this
 document should seek competent professional advice to verify and
 assume responsibility for the suitability of this information to their
 particular situation.