Spartan Chemical Company, Inc.
Material Safety Data Sheet
Show details for SECTION I: PRODUCT INFORMATIONSECTION I: PRODUCT INFORMATION
Hide details for SECTION I: PRODUCT INFORMATIONSECTION I: PRODUCT INFORMATION

Product Name or Number (as it appears on label): Product Division:
SC-200
Product Number: 2200
 Janitorial
Spartan Chemical Company, Inc.
Product/Technical Information:
 1-(800)-537-8990
1110 Spartan Drive
Medical Emergency:
 1-(888)-314-6171 (24 hours)
Maumee OH 43537
Chemical Leak/Spil Emergency:
 CHEMTREC 1-(800) 424-9300 (24 hours)
Shipping Description:
 Corrosive liquids, n.o.s., 8, UN 1760, II, (contains sodium hydroxide)
NFPA Ratings:
HMIS Ratings:
Health:
 3 - Serious
Health:
 *3 - Serious; Chronic Hazard
Fire:
 0 - Minimal
Fire:
 0 - Minimal
Reactivity:
 0 - Minimal
Reactivity:
 0 - Minimal
Pers. Prot. Equip.:
 See Section VIII

Show details for SECTION II: HAZARDOUS INGREDIENTSSECTION II: HAZARDOUS INGREDIENTS
Hide details for SECTION II: HAZARDOUS INGREDIENTSSECTION II: HAZARDOUS INGREDIENTS
(Listed when present at 1% or greater, carcinogens at 0.1% or greater) All component chemicals are listed or exempted from listing on the "TSCA Inventory" of chemical substances maintained by the U.S. Environmental Protection Agency.
Chemical Name(s)
% W
CAS Registry No.
Table Z- 1 - A
NTP, IARC or OSHA Carcinogen
TWA mg/m3
STEL mg/m 3
CELING mg/m3
*2-Butoxyethanol
5-10
111-76-2
240 [skin] 96
Not Established
Not Established
No
Alcohol ethoxylate
1-5
68439-46-3
Not Established
Not Established
Not Established
No
Sodium xylene sulfonate
1-5
1300-72-7
Not Established
Not Established
Not Established
No
Sodium hydroxide
1-5
1310-73-2
2
Not Established
Not Established
No

Comment: *This substance is subject to the reporting requirements of Section 313 of the Emergency Planning and Community Right-To-Know Act of 1986 (SARA) and of 40 CFR 372.


Show details for SECTION III: PHYSICAL DATASECTION III: PHYSICAL DATA
Hide details for SECTION III: PHYSICAL DATASECTION III: PHYSICAL DATA
Boiling Point:
 210 °F
Vapor Pressure:
 Unknown
Vapor Density (AIR = 1):
 Unknown
Solubility in Water:
 Complete
pH:
 13.4 - 13.9
Specific Gravity (H2O=1):
 1.063
Evaporation Rate (but.ace.=1):
 <1
Percent Solid by Weight:
 14-15
Physical State:
 Liquid
Appearance & Odor:
 Red liquid, glycol ether odor
Show details for SECTION IV: FIRE & EXPLOSIVE HAZARD DATASECTION IV: FIRE & EXPLOSIVE HAZARD DATA
Hide details for SECTION IV: FIRE & EXPLOSIVE HAZARD DATASECTION IV: FIRE & EXPLOSIVE HAZARD DATA

Flash Point:
 > 210°F
Method Used:
 ASTM-D56
Flammable Limits:
 Not Established
Flame Extension:
 N/A
Extinguishing Media:
 Product does not support combustion. Use extinguishing media appropriate for surrounding fire.
Special Fire Fighting Procedures:
 Wear NIOSH approved self-contained breathing apparatus and protective clothing. Cool fire-exposed containers with water spray.
Unusual Fire & Explosive Hazards:
 Combustion products are toxic.
Show details for SECTION V: HEALTH HAZARD DATASECTION V: HEALTH HAZARD DATA
Hide details for SECTION V: HEALTH HAZARD DATASECTION V: HEALTH HAZARD DATA
Threshold Limit Value:
 Not Established
Primary Routes of Entry:
 Inhalation, Skin Contact, Eyes & Oral
Effects of Overexposure-
Conditions to Avoid:
 CORROSIVE:
CAUSES EYE AND SKIN BURNS: Symptoms include chemical burns, pain, redness, swelling of the conjunctiva and tissue destruction.
HARMFUL CONTACT MAY NOT CAUSE IMMEDIATE PAIN.
HARMFUL IF SWALLOWED: Causes damage or chemical burns to esophagus and mucous membranes with symptoms of pain, nausea, vomiting and diarrhea. Aspiration of product into the lungs may occur during ingestion or vomiting, resulting in lung injury.
HARMFUL IF INHALED: Breathing product vapor or mist may cause irritation or damage of the respiratory tract, with symptoms of nasal discomfort and discharge with chest pain and coughing.
HARMFUL IF ABSORBED THROUGH SKIN:
Contains 2-butoxyethanol which may cause central nervous system depression with symptoms such as headache; dizziness; nausea and drowsiness. Exposure to 2-butoxyethanol may cause blood cell; liver and kidney damage based on animal data.
DO NOT GET IN EYES, ON SKIN OR CLOTHING. DO NOT BREATHE PRODUCT VAPOR OR MIST. DO NOT SWALLOW. USE WITH ADEQUATE VENTILATION. WASH THOROUGHLY AFTER HANDLING.
Conditions Aggravated by Use:
 Use of this product may aggravate preexisting skin; eye and respiratory disorders including asthma and dermatitis.
Emergency & First Aid Procedures:
Eyes:
 Immediately flush eyes with plenty of water for at least 15 minutes. Remove contact lenses. Get medical attention.
Skin:
 Remove contaminated clothing and shoes. Flush skin with water for at least 15 minutes. Get medical attention if irritation persists. Wash contaminated clothing before reuse. Destroy contaminated shoes.
Ingestion:
 Call a poison control center or doctor immediately for treatment advice. Do not induce vomiting. Drink one or two glasses of water to dilute product. Do not give anything by mouth to an unconscious person.
Inhalation:
 In case of respiratory irritation or dizziness; move person to fresh air. If not breathing; give artificial respiration. If breathing is difficult; give oxygen. Get medical attention if irritation persists.


Show details for SECTION VI: REACTIVITY DATASECTION VI: REACTIVITY DATA
Hide details for SECTION VI: REACTIVITY DATASECTION VI: REACTIVITY DATA

Stability:
 Stable
Incompatible Materials:
 Strong acids and oxidizing agents
Hazardous Decomposition Products:
 Not established
Hazardous Polymerization:
 Will Not Occur

Show details for SECTION VII: SPILL OR LEAK PROCEDURESSECTION VII: SPILL OR LEAK PROCEDURES
Hide details for SECTION VII: SPILL OR LEAK PROCEDURESSECTION VII: SPILL OR LEAK PROCEDURES
Steps to be Taken in Case
Material is Released or Spilled:
 Dike and contain spill with inert material (sand, earth, commercial absorbent, etc.) and transfer to containers for disposal. Rinse area with water and flush to sanitary sewer. Keep spill out of storm sewers and waterways.
Waste Disposal Method:
 Dispose of in compliance with all federal, state and local laws and regulations.

Show details for SECTION VIII: SPECIAL PROTECTION INFORMATIONSECTION VIII: SPECIAL PROTECTION INFORMATION
Hide details for SECTION VIII: SPECIAL PROTECTION INFORMATIONSECTION VIII: SPECIAL PROTECTION INFORMATION

Respiratory Protection:
 Not normally required when good general ventilation is provided. However if exposure limits are exceeded (see Section II) or if respiratory irritation occurs, the use of a NIOSH approved respirator suitable for the use-conditions and chemicals listed in Section II should be considered. (N95 or greater with organic vapor cartridge recommended)
Ventilation:
 Provide good general ventilation. Local exhaust ventilation may be necessary for some operations.
Protective Gloves(Specify Type):
 Solvent/alkali resistant gloves such as neoprene, nitrile or natural rubber.
Eye Protection(Specify Type):
 Splash goggles are recommended to prevent eye contact.
Other Protective Equipment:
 Solvent /alkali resistant boots, apron and other protective equipment is recommended when foot / body contact is likely. Eye wash stations and washing facilities should be readily accessible in areas where product is handled. See 29 CFR 1910.132-138 for further guidance.

Show details for SECTION IX: SPECIAL PRECAUTIONSSECTION IX: SPECIAL PRECAUTIONS
Hide details for SECTION IX: SPECIAL PRECAUTIONSSECTION IX: SPECIAL PRECAUTIONS

Precautions; Handling & Storing:
 Keep container tightly closed. Store in a cool, dry area. Do not freeze. Do not store above 120°F. Do not mix with other chemicals.
Other Precautions:
 Keep out of reach of children

© SCC 05/15/2007 Name: Ronald T. Cook Title: Manager, Regulatory Affairs
SC-200 Effective Date: 05/15/2007 Supercedes: 04/30/2007
Ref: 29 CFR 1910.1200 (OSHA) Changes: Update Section VIII
This document has been prepared using data from sources considered technically reliable. It does not constitute a warranty, express or implied, as to the accuracy of the information contained herein. Actual conditions of use and handling are beyond sellers control. User is responsible to evaluate all available information when using product for any particular use and to comply with all Federal, State and Local laws and regulations.